ABOUT

Solutions & Cases

Our Case
  • Recycling Concrete Cembureau

    Recovered concrete from C&DW can be crushed and used as aggregate, mainly for road bases and sub-bases, but new concrete can also be made using a percentage of recovered crushed concrete. The hardened cement fraction from recovered concrete provides a good opportunity for recycling into the cement clinker process.

  • Recycling of End of Life Concrete Fines into Hardened

    quality assurance and fines that can be processed (off-site) into Ca-rich material for new clinker production. In situ recycling of the aggregate is one of the primary goals of the C2CA. In the C2CA process, after crushing of EOL concrete, autogenous milling is used to remove the loose mortar from the surface of the aggregates.

  • Recovery of residual anhydrous clinker in finely ground

    2020. 4. 1.· This study suggests that residual anhydrous clinker is present in old waste concrete and can be recovered by grinding. This statement is supported by microscopical observation, XRF, and calorimetry measurements. Mixing ground waste concrete with Portland cement had beneficial effects on the mechanical properties of cementitious pastes.

  • (PDF) Recovery of residual anhydrous clinker in finely

    clinker is present in waste concrete and can be recovered by grinding. Replacing Portland cement with the recycled material in pastes led to a significant increase of tensile strength, while deterio-

  • Recycled concrete sand as alternative raw material for

    2020. 11. 27.· As explained in the general introduction, considering the fine fraction of crushed demolition concrete as alternative raw materials for Portland clinker production is one of the three options for recycling concrete. This way of recycling sands from crushed concretes 64is based on the rough assumption that the chemical and mineralogical composition of a given concrete is mainly governed

  • Formation Kinetics of Regenerated Cement Clinker

    Regenerated cement clinker is fabricated by recycling concrete powder added with a small amount of correction raw materia. Through the Gentling equation computing and microstructure morphology observation, the apparent activation energy (Ea) of two kinds of regenerated cement clinkers are 199 kJ/mol and 333 kJ /mol respectively, which is lower than that of traditional cement clinker (518 kJ/mol).

  • The Cement Sustainability Initiative

    2018. 7. 25.· Rather, concrete is broken down into smaller blocks or aggregate for use in a new life. In this report “recycled concrete” refers to concrete that has Some myths and truths about concrete recycling Once cement clinker is made, the process is irreversible. No commercially viable processes exist to recycle cement.

  • Fines extracted from recycled concrete as alternative raw

    2015. 4. 1.· In this study, it was shown that the fines fractions generated out of concrete recycling could be used as an alternative raw material (ARM) for Portland clinker production. No major influence on the mineralogy of the final clinker was demonstrated by using recycled fines as alternative raw material.

  • Cement, concrete & the circular economy

    2018. 2. 15.· Thanks to material recycling in the cement industry, the mineral content of waste used as an alternative fuel serves as a raw material for the production of clinker, the main constituent in cement. In a nutshell, EU policy should: ssFoster the use of waste to achieve the EU targets set for waste recycling and resource efficiency.

  • A short look at low carbon cement and concrete Cement

    Solidia isn’t the only company looking at two complementary technologies along the cement-concrete production chain. A number of companies are looking at recycling concrete and demolition waste. Generally this splits into coarse waste that is used as an aggregate substitute in concrete and fine waste that is used to make cement.

  • (PDF) Recovery of residual anhydrous clinker in finely

    clinker is present in waste concrete and can be recovered by grinding. Replacing Portland cement with the recycled material in pastes led to a significant increase of tensile strength, while deterio-

  • Recycled concrete sand as alternative raw material for

    2020. 11. 27.· As explained in the general introduction, considering the fine fraction of crushed demolition concrete as alternative raw materials for Portland clinker production is one of the three options for recycling concrete. This way of recycling sands from crushed concretes 64is based on the rough assumption that the chemical and mineralogical composition of a given concrete is mainly governed

  • Fines extracted from recycled concrete as alternative

    2015. 4. 1.· In this study, it was shown that the fines fractions generated out of concrete recycling could be used as an alternative raw material (ARM) for Portland clinker production. No major influence on the mineralogy of the final clinker was demonstrated by using recycled fines as alternative raw material.

  • Scientists Use Lightning Blasts To Recycle Old Concrete

    The key to recycling concrete, and curbing some of these harmful carbon emissions, is efficiently reducing concrete rubble into ingredients that can then be mixed into new concrete.

  • Recycling of End of Life Concrete Fines into Hardened Cement and Clean Sand

    The C2CA (Concrete to Cement and Aggregate) concrete recycling process aims at a cost-effective system ap- proach for recycling highvolume End Of Life (EOL) concrete streams into prime- -grade

  • Clinker Substitution Cembureau

    Clinker can be blended with a range of alternative materials, including pozzolans, finely ground limestone and waste materials or industrial by-products. The clinker-to-cement ratio (percentage of clinker compared to other non-clinker components) has an impact on the properties of cement so standards determine the type and proportion of alternative main constituents that can be used.

  • Activated Low Clinker Slag Portland Cement and Concrete

    2020. 12. 17.· Low-clinker cements filled with industrial wastes have several positive features: low cost, less energy intensive production process, recycling of

  • The Environmental Impact of Recycled Concrete

    2012. 8. 14.· clinker (Kumar et al, 2006). A building made of reinforced concrete structure is demolished at the end of its lifecycle and its residues are normally sent to the landfills. Nevertheless, all the concrete mass treated as waste can be incorporated into new concretes in the

  • Using Lightning to Recycle Concrete? Innovation Toronto

    Researchers are working on new recycling methods, and with the aid of lightning bolts, they can break down the mixture of cement and aggregate into its components. Whether the Pantheon in Rome or the German concrete canoe regatta, whether ultra-light or decorative: concrete is unbelievably versatile and is the world’s most widely used material next to water.

  • A short look at low carbon cement and concrete

    Solidia isn’t the only company looking at two complementary technologies along the cement-concrete production chain. A number of companies are looking at recycling concrete and demolition waste. Generally this splits into coarse waste that is used as an aggregate substitute in concrete and fine waste that is used to make cement.